Continental Express Flight 2574

Continental Express Flight 2574

Wreckage of Flight 2574
Accident
Date	September 11, 1991 (1991-09-11)
Summary	In-flight structural failure due to maintenance error leading to in-flight breakup.[1]
Site	Colorado County, near Eagle Lake, Texas, USA 29°31′38″N 96°23′21″W / 29.52722°N 96.38917°W / 29.52722; -96.38917
Aircraft
Aircraft type	Embraer EMB 120RT Brasilia
Operator	Britt Airways, Inc., dba Continental Express
IATA flight No.	RU2574
ICAO flight No.	BTA2574
Call sign	JETLINK 2574
Registration	N33701
Flight origin	Laredo International Airport, Laredo, Texas, United States
Destination	Houston Intercontinental Airport, Houston, Texas, United States
Occupants	14
Passengers	11
Crew	3
Fatalities	14
Survivors	0

Continental Express Flight 2574 (Jetlink 2574) was a scheduled domestic passenger airline flight operated by Britt Airways^[2] from Laredo International Airport in Laredo, Texas to Houston Intercontinental Airport (IAH) (now called George Bush Intercontinental Airport) in Houston, Texas. On September 11, 1991, the Embraer EMB 120 Brasilia turboprop, registered N33701,^[3] crashed while initiating its landing sequence, killing all 14 people on board. The aircraft wreckage hit an area near Eagle Lake, Texas, approximately 65 miles (105 km) west-southwest of the airport.

The media stated that there was initial speculation that a bomb had destroyed the aircraft; the National Transportation Safety Board (NTSB) subsequently discovered that missing screws on the horizontal stabilizer led to the breakup.^[4]

The involved was an Embraer 120RT Brasilia, registered as N33701 with serial number 120077. It was delivered to Continental Express in 1988, three years before the accident, and had accumulated 7,229 flight hours through 10,009 cycles.^[1]: 8 The Federal Aviation Administration records stated that the aircraft had been sent to the maintenance hangar 33 times for unscheduled repairs.^[5]

The crew consisted of 29-year-old Captain Brad Patridge of Kingwood, Texas (Greater Houston), 43-year-old First Officer Clint Rodosovich of Houston and 33-year-old Flight Attendant Nancy Reed of Humble, Texas.^[6] Patridge and Rodosovich were experienced pilots with 4,243 flight hours and 11,543 flight hours (including 2,468 hours and 1,066 hours on the EMB 120 Brasilia), respectively. Both pilots and the flight attendant were all based in Houston.^[1]: 5

The EMB 120 departed Laredo International Airport at 09:09 local time, operating under Federal Aviation Regulation Part 135. After a normal takeoff, the flight was assigned a cruise altitude of flight level 250 (25,000 feet (7,600 m)), then reassigned to FL240 (24,000 feet (7,300 m)). At 09:54, the flight crew responded to the Houston Air Route Traffic Control Center and started descending to 9,000 feet (2,700 m). At approximately 10:03 while descending through 11,500 feet (3,500 m) with an indicated airspeed of 260 knots (300 mph; 480 km/h), the leading edge of the left horizontal stabilizer separated from the airframe, and the airplane pitched down dramatically, rolling around on an axis as the left wing broke and folded.^[1] The escaping fuel from the wings ignited, and the pilots and others onboard lost consciousness from the severe g-forces, which reached at least 3.375 times the force of gravity,^[1] caused by the severe oscillations of the crippled aircraft.

The wreckage fell in southeast Colorado County, Texas, exploding on impact, off Farm to Market Road 102, seven miles (11 km) southeast of Eagle Lake, Texas,^[7] and 60 miles (97 km) west of Downtown Houston.^[8] The Texas Department of Public Safety announced that rescue units had discovered no survivors.^[7] The wreckage was spread over a 2- to 4-square-mile (10 km²) area, and some pieces fell into the Colorado River.^[8] Diamonds worth approximately $500,000 (1991 value; $1,100,000^[9] in 2023) were discovered in the wreckage, but they had no role in the crash.^[6]

The National Transportation Safety Board (NTSB) investigation revealed that screws had been removed from the horizontal stabilizer during maintenance the night before the accident and, following a shift change, the screws had not been replaced.^{[1]: 48, 49} The aircraft's first flight of the day was uneventful because it did not reach the accident flight's top speed of 260 knots (480 km/h; 300 mph).^[1]

The NTSB cited the failure of airline maintenance and inspection personnel to adhere to proper maintenance and quality-assurance procedures. The failure of Federal Aviation Administration (FAA) surveillance to detect and verify compliance with approved procedures was cited as a contributing factor.^[1]: 49 Following the accident, the FAA conducted a National Aviation Safety Inspection Program (NASIP) of Continental Express' maintenance program. It found very few safety deficiencies and complimented the airline on its internal evaluation system. The NTSB expressed concern that the NASIP did not find deficiencies in shift-turnover procedures and other matters relevant to the accident and recommended that the agency improve its NASIP procedures.^{[citation needed]}

The NTSB determined the probable causes of the accident as follows:

The failure of Continental Express maintenance and inspection personnel to adhere to proper maintenance and quality assurance procedures for the airplane's horizontal stabilizer de-ice boots that led to the sudden in-flight loss of the partially secured left horizontal stabilizer leading edge and the immediate severe nose-down pitchover and breakup of the airplane. Contributing to the cause of the accident was the failure of the Continental Express management to ensure compliance with the approved maintenance procedures, and the failure of FAA surveillance to detect and verify compliance with approved procedures.^[1]: 50

Some experts say that the crash of Continental Express Flight 2574 was the most dramatic turning point for "safety culture" in the United States.^[10] NTSB member Dr. John Lauber suggested that the probable cause of the accident included "The failure of Continental Express management to establish a corporate culture which encouraged and enforced adherence to approved maintenance and quality assurance procedures."^[1]: 54 As a result of this and other similar aviation accidents, safety culture became the main topic at the U.S. National Summit on Transportation Safety, hosted by the NTSB in 1997.^{[citation needed]}

This movement for air safety continued with the April 5, 2000 enactment of the Wendell H. Ford Aviation Investment and Reform Act for the 21st Century, also called AIR 21.

The Discovery Channel Canada / National Geographic TV series Mayday featured the accident in a Season 11 episode titled "Breakup Over Texas."^[11]

Smithsonian Channel also featured this episode in its series Air Disasters (2013, Season 3, Episode 6.)

• List of accidents and incidents involving commercial aircraft

• Atlantic Southeast Airlines Flight 2311, another EMB-120 that crashed due to similar problems before landing earlier in the same year.
• Alaska Airlines Flight 261, a flight that suffered a catastrophic loss of control after improper repairs from jackscrew few years prior.
• China Airlines Flight 611, a flight that suffered a catastrophic mid-air breakup after improper repairs from a tail strike 22 years prior.
• Japan Air Lines Flight 123, a flight accident caused by a faulty tailstrike repair 7 years prior.
• Chalk's Ocean Airways Flight 101, a case where a wing separated from a flight after improper corrosion repairs to the aircraft.
• Aloha Airlines Flight 243, an aircraft that suffered an explosive decompression after improper corrosion repairs.
• Far Eastern Air Transport Flight 103, a flight that disintegrated in midair after improper corrosion repairs.
• Partnair Flight 394, a flight that disintegrated in midair due to improper maintenance and use of counterfeit aircraft parts.
• BOAC Flight 781, a flight that suffered an explosive decompression in midair due to metal fatigue from a construction flaw.

 This article incorporates public domain material from websites or documents of the National Transportation Safety Board.

• NTSB abstract
• NTSB letter
• Aircraft One data
• Horswell, Cindy, T. J. Milling, Rad Sallee. "Crash in Colorado County/Attendant on doomed aircraft had resigned to take a new job."^{[dead link‍]} Houston Chronicle. Saturday September 14, 1991. A27. Available from the Houston Public Library newspapers section Archived June 27, 2021, at the Wayback Machine, accessible with a library card and PIN